The Chrysler Minivan Fan Club Forums banner

Discussions Showcase Albums Media Media Comments Tags Marketplace

1-20 of 22 Results
  1. 4th Generation Chrysler Minivans: 2001-2007
    Summer of ‘23 I was in Virginia Beach in a rain storm and my “trac off” light came on along with my battery light & my blower motor came on. The power light on the HVAC control was off and unresponsive to button presses. I parked it until September when I could replace the alternator. (It was...
  2. 4th Generation Chrysler Minivans: 2001-2007
    My used, recently acquired 2006 Dodge Grand Caravan had a rear HVAC system. It seems to reach operating temperature in a reasonable amount of time, but once it reaches operating temperature, it can get hot. Seriously hot. I don't recall ever having a vehicle that gets as hot as this one. It's 39...
  3. 5th Generation Chrysler Minivans: 2008-2020
    @Michalb, I remember you saying to someone one here that their issue with with their rear blower randomly coming on may be an issue with the harness under the driver's seat. Do you know how this harness is routed and where the common failure point on it usually is? I'm having the same symptoms...
  4. 6th Gen Pacifica 2017+ Voyager 2020+ Caravan 2021+
    Hi all, I'm getting mad on this small bug and I would like to understand if I'm the only one in the world or if there is any solution to this oddity. My '17 pacifica has a 3 way manual climate system and it works fine. The strange things is that the bars on the 8 inch screen are not sync with...
  5. 5th Generation Chrysler Minivans: 2008-2020
    My wife and I are looking at buying a 5th gen Dodge Grand Caravan. The old '01 baseline model is starting to succumb to northern rust. I've seen that it's common for the HVAC system to have two zones on this generation. Naturally, cheapskate me sees this as just another thing to go wrong...
  6. 4th Generation Chrysler Minivans: 2001-2007
    Heyyyy! On this chapter of “My Van Hates Me and Wishes Me Premature Death”, I am experiencing some more issues with the AC. It’s probably my fault, but I digress. So last fall, the family members who gave it to me said it needed a new blower motor. Done and installed. Unfortunately I knew less...
  7. 5th Generation Chrysler Minivans: 2008-2020
    2010 Dodge grand caravan 3.8L Sounds crazy but it does happen photos.app.goo.gl/yPTDXabXgUkaQkoHA (sorry for the terrible video but you can hear the change in airflow and see the hvac controls) It cycles from defrost to full hot and full cold. I had just replaced the window regulator and had...
  8. 5th Generation Chrysler Minivans: 2008-2020
    I have a 2012 Caravan. The front and rear HVAC is not working. When I turn on the A/C I can see a dip in RPM, but that's about it. I went to the dealership and they were going to charge me almost $200 just for a diagnosis. I would also have to wait a minimum of 3 hours to find out what's wrong...
  9. 3rd Generation Chrysler Minivans: 1996-2000
    1999 Plymouth Grand Voyager: When I press the recirculation button, I hear it actuate, then all the airflow stops and seems to be trapped in the box with a little leakage. Clearly some flap actuator is malfunctioning. Wondering if anyone has any familiarity with the HVAC box before I go tearing...
  10. 4th Generation Chrysler Minivans: 2001-2007
    Help! First let me say that it is possible the AC compressor is shot as it's not clicking on and off and not getting cold air when set to AC. However, we are confounded by the fact that van only blows HOT AIR no matter WHAT the air temp is outside UNLESS it's set to LOW with the AC set to OFF...
  11. 5th Generation Chrysler Minivans: 2008-2020
    Hi, I am new to the forum. I have a 2008 Chrysler Town & Country Touring with 113k miles on it. Last week the HVAC Recirculation Door Actuator started to make grinding/clicking noise and the recirculation button on the HVAC control started to blink. I took the old actuator out and opened it...
  12. 5th Generation Chrysler Minivans: 2008-2020
    Hello all, First post on the forum so go easy on me :) Desperate for a solution...decided to spend some time working on my wife's 2010 T/C touring yesterday. I had to replace the ERG valve for a code, after fighting with that I decided to change the front blower motor that I had ordered a...
  13. 4th Generation Chrysler Minivans: 2001-2007
    I bought an 04 Pacifica before I researched it. Had I done that, I would have ran as fast as I could. The heater went out (at 40 below zero). The blower has power even when turned off as long as the key is on (not off). I have replaced the blower motor, the resistor, the connector, and even the...
  14. 4th Generation Chrysler Minivans: 2001-2007
    I've got a clog in the AC condensation drain line in my 2006 Grand Caravan with 3.8 V6. I know how to unclog it if I can find the darned thing but I am just not seeing it. Maybe I'm going blind, or perhaps Chrysler has hidden it behind something? If you know where the drain hole (or hose) is...
  15. 5th Generation Chrysler Minivans: 2008-2020
    How do I calibrate the HVAC system? It's a 2012 STX with the dual zone climate. I can find lots of instructions for previous generation vans but not this one. The problem is that when I start it up the rear defrost light flashes and all the controls are locked out for 60 seconds or so. You can...
  16. 3rd Generation Chrysler Minivans: 1996-2000
    I'm about to begin the reassembly process for my 1999 GCSE after finding the evaporator had a sizable leak. Right now I'm looking at the blower fan and it does not spin freely. It has a bit of resistance. Now that may or may not be a bad thing depending on the internal construction. But it...
  17. 4th Generation Chrysler Minivans: 2001-2007
    Recently, every time we start our 02 grand caravan, the climate control (manual version) is powered on and the A/C button is illuminated. I only noticed because the van was started and idling and I heard the compressor kicking on. Since I noticed, it has done it nearly every start up for over a...
  18. 5th Generation Chrysler Minivans: 2008-2020
    Hello - In my 2008 T&C Touring, the front blower motor begins squealing at the speeds one and two notches above off. Is there anything that can be greased to alleviate this or must I replace the motor in order to stop the squealing? Thank you.
  19. 4th Generation Chrysler Minivans: 2001-2007
    It's warm outside and the van is not cooling the air. So, I charged it up and the gauges show no pressure. Since the van was running I could not hear anything and I walked around the back to the passenger side and heard a loud hissing sound. So, I am assuming that one or more of the rear AC...
  20. 5th Generation Chrysler Minivans: 2008-2020
    I have an 08 T&C ltd with auto air. I cannot get the air to blow to the window or the upper vents. It only comes out at my feet. Neither the defrost button or manually changing the air direction has any effect. The display that indicates where the air should be going changes when I push the...
1-20 of 22 Results
Top