The Chrysler Minivan Fan Club Forums banner

Discussions Showcase Albums Media Media Comments Tags Marketplace

1-20 of 40 Results
  1. 5th Generation Chrysler Minivans: 2008-2020
    Evening folks, 2012 Town and Country Touring with 170K, 3.6 engine and 4730 engine hours. As i type this my van is in the shop for an alternator replacement. Sunday night the original one died, letting its ghost escape in smoke and the smell of burning wires. After that the van was a complete no...
  2. 4th Generation Chrysler Minivans: 2001-2007
    Was checking on some wiring and found this connector dangling towards the PCM area. Does anyone know what this connector is for or where it goes? Asking so I don't have to remove my battery and IPM module for nothing 😂 Side note I've been having some electrical problems. Misfiring at idle...
  3. 4th Generation Chrysler Minivans: 2001-2007
    I fixed the inj harness which 5 volt ref was shorted to sensor ground. When I check with koeo I get normal tempature readings 199 deg but when I start the engine it drops down to 45 deg. Temp sensor is new. while running I still have 5 volts on map sensor.
  4. 5th Generation Chrysler Minivans: 2008-2020
    I have a bad PCM on my 2012 Grand Caravan, and I'm looking at the option of replacing it myself with a refurbished unit rather than a "new" unit through my mechanic. Cost savings looks to be about $1000, but I am a little leery as the new ones need to be flashed and the websites advertising...
    pcm
  5. 4th Generation Chrysler Minivans: 2001-2007
    Hi, I want to start off by saying I am homeless and live in my van so keep that in mind when thinking about my situation. Thanks! My 2001 DGC Sport, 175K miles, is in the shop the mechanic said the PCM was giving out a bunch of codes and I need a new one. I brought it in because , not all the...
  6. 4th Generation Chrysler Minivans: 2001-2007
    I did the injector harness “repair” and it seemed fine at first, it was warm that day. Today it was cold and the same symptoms exist as if the harness is still shorted. I checked my work at the harness and found the wires to still be well insulated. (My previous post) I got a code p0601 and it...
  7. 4th Generation Chrysler Minivans: 2001-2007
    i bought a used 05 (3.8L) thi is the 3rd ive owned 03,07,05 less than 3000 miles in (has 171K now) the van went into limp mode at 4am of coarse every trans shop says need new transmission. (error code for shift solenoid i replaced THREE times didnt fix) so its been like 2 months now of it...
  8. 4th Generation Chrysler Minivans: 2001-2007
    Will summarize my current issue since the '01 service manual for my 212k 3.3L '01GC is not crystal clear to me (chapter 25 and 8E): 1) Had to replace the PCM which was reprogrammed with the VIN and mileage. 2) No codes are being thrown. 3) Emission passes, but since the PCM doesn't report...
  9. 4th Generation Chrysler Minivans: 2001-2007
    Hi! I have been working on my cousins van. 2007 Town and Country 170k It came to me with the van not starting and the battery flat. I tested the starter and battery (after charging for a day). The van would click at the fuse box, but not turn over. Other symptoms were no instrument cluster...
  10. 4th Generation Chrysler Minivans: 2001-2007
    Well, it's my first post and I'll leave my experience at the end to not bore everyone with lame details and get right to the problem. However, this will be detailed to try to give as much info as possible to try to get as much help as possible. If you're not into details or long posts, I'm...
  11. 4th Generation Chrysler Minivans: 2001-2007
    So I have come into possession of a 06 GC. The story goes like this.the lady was driving back from Calgary Alberta to north Battleford Saskatchewan. Van craped out and wouldn't start. They got it towed home and tried working on it Well I have a parts ban I've been using so I gave em a new coil...
  12. 3rd Generation Chrysler Minivans: 1996-2000
    This is a continuation of a prior thread Cam or Crank Shaft Sensor or Fuel Problem - Opinions Appreciated which I feel engine components of that thread were addressed. However, I still have a "no start" situation and I am confident it is not due to crank or cam shaft sensors or the coil - as...
  13. 4th Generation Chrysler Minivans: 2001-2007
    **** All I have 2003 grand caravan 3.89L Sport and I had error on diagnostic that stated Injectors 5/6 open. I replaced Injector 5/6 and also install new wire harness. I ran Diagnostic again as van still running rough and still show injectors 5/6 open. I there a lower harness to PCM? Can the PCM...
  14. 3rd Generation Chrysler Minivans: 1996-2000
    Hello. Long time reader first time posting. I have researched my issue until sheer insanity. Would love your thoughts as i just cant quit her. 1. Fist symptom was temp guage stopped working and the fans run upon start. I did the push button test on the speedometer and it worked accordingly...
  15. 4th Generation Chrysler Minivans: 2001-2007
    Since a few weeks I have a Chrysler 2002 Minivan. The problem is that I can not read the section Powertrain, ECM etc with my Foxwell NT510 Chrysler. BCM is also not possible. Manual input Vin code can not be decoded. Othr items I can read, Airbag, Whipers, Lights, ABS, SKIM... Selection of the...
  16. 5th Generation Chrysler Minivans: 2008-2020
    Has anyone replaced their PCM in a 5th Gen, 2008 Grand Caravan? The dealer wants $1200 for the new PCM and installation. Can a used PCM from another vehicle be flashed so it will work in another vehicle? Is there a way to buy a new one cheaper and get it flashed so it can be installed?
  17. 5th Generation Chrysler Minivans: 2008-2020
    Fixed the bad fuel pump relay, fixed the no start relay, installed a new battery, new alternator, new pulley's and belt, battery still not charging. Replaced every single connector on the TIPM to be sure I had good connections. Everything points to bad ECM, but I can't seem to find one and...
  18. 4th Generation Chrysler Minivans: 2001-2007
    2005 Grand Caravan, SXT w/ 3.8L V6 150k miles. January 22nd -- Replaced Power Steering reservoir for noise issue. Good Fix. I think I rinsed the old fluid off with gentle water pressure and caused the next problem -- January 24th -- Went to drive it and had severe misfire issue. Plug...
  19. 2nd Generation Chrysler Minivans: 1991-1995
    This one has me about to go nuts. 1993 Caravan 2.5 5 speed manual trans. 268K miles, up until now it just always works. Now it starts and runs fine, but no check engine light during startup and speedo, odometer, temp gauges don't work. Domelights don't work except manually on the lights, but...
  20. 4th Generation Chrysler Minivans: 2001-2007
    3.8l v6. cooling fans not running even when ac on. jumper tested fans at relay and they run. prior to me owning it, it appears someone made numerous repairs to wires under the ipm. the baffling problem is that i noticed a nick in insulation in the brown/violet wire coming from the pcm, and...
1-20 of 40 Results
Top