The Chrysler Minivan Fan Club Forums banner

Discussions Showcase Albums Media Media Comments Tags Marketplace

1-20 of 23 Results
  1. 5th Generation Chrysler Minivans: 2008-2020
    I'm hoping someone can give me an idea to check. I have a 2012 with 3.6L vvt Flex-fuel. My wife came home day before yesterday and everything was fine. Yesterday morning I hit the auto start and everything was fine. About 5 min later it sputtered and died. I couldn't get it to restart. There...
  2. 5th Generation Chrysler Minivans: 2008-2020
    So my 2012 dodge caravan (3.6) had the flex plate replaced about a month ago. Check engine light is on and it's been ticking, and intermittently running rough, hard idle, jerking with acceleration (fine coasting) almost like it doesn't have gas. Took to advance, they scanned it it came back with...
  3. 4th Generation Chrysler Minivans: 2001-2007
    Half way through warm up it will putter hard and stumble...sometimes stall...fans will come on and off...but when it reaches full temperature it smooths back out and runs fine... I changed the CAM and CRANK SHAFT Sensors but still the same..the sparkplugs and wires are about a year old..and I...
  4. 4th Generation Chrysler Minivans: 2001-2007
    I did the injector harness “repair” and it seemed fine at first, it was warm that day. Today it was cold and the same symptoms exist as if the harness is still shorted. I checked my work at the harness and found the wires to still be well insulated. (My previous post) I got a code p0601 and it...
  5. 4th Generation Chrysler Minivans: 2001-2007
    About October 2020ish, I stepped out late at night for a beer run & it had gotten chilly (around 48°f) when I cranked the van it started but sputtered like crazy as if it was running on 2 cylinders and it ran that way for about a minute then smoothed out to normal. The next day it was around 70°...
  6. 5th Generation Chrysler Minivans: 2008-2020
    T&C 3.8L V6, vans runs fine for a while then it stalls out at red light, like a rough idle. Start then engine up, start driving and runs fine for about 5 miles (or ~10 min down the road) but the first red light I hit after that the van starts to rough idle and stalls out with no check engine...
  7. 4th Generation Chrysler Minivans: 2001-2007
    Hello I have a 2003 Dodge Grand Caravan sport. 3.8L v6 with 225500kms on it. The van had a slight vibration to it going above 80kmh. Later that night as I went up to a light it started vibrating much rougher and sounded like it was gonna stall. I threw it in neutral and revved it till the light...
  8. 3rd Generation Chrysler Minivans: 1996-2000
    Evening All- My 2000 T&C with the 3.8L has a rough idle. Diagnostic reports Cylinder #5 misfire. I have- Checked compression 150 psi Swapped out #5 plug and wire, no change Swapped out #5 injector, no change Swapped out coil pack, no change 220K miles Any ideas here? Thanks in advance
  9. 4th Generation Chrysler Minivans: 2001-2007
    Yesterday morning I developed a heavy vibration / shaking / shuddering, especially under load or accelerating, but also definitely a more rough idle. The van threw the P0302 code (misfire on cylinder 2) so I changed the plug and swapped wires with another cylinder. The old plug was gapped at...
  10. 5th Generation Chrysler Minivans: 2008-2020
    On my 2011 G/C with a 3.6, Getting P0132, P0172, P0300 codes, intermittently running rough at idle, and occasionally when decelerating. Going to try the b1s1 o2 sensor, worried about the head problem on this van. Any body ever see this before?
  11. 4th Generation Chrysler Minivans: 2001-2007
    Hello All!! I recently bought a 2001 3.8 T&C from a friend for $1!!!! its a rough looking van but i have it since last July and up until now haven't really had any issues. So i will get right into whats going on with it now. - Starts up fine but when in park it will struggle to idle, it revs...
  12. 4th Generation Chrysler Minivans: 2001-2007
    Hey guys, I have an'04 T&C, 160K miles, which has a rough idle. I hooked up a scanner to the vehicle yesterday and here's what I found. STFT -3 LTFT 16 Increase in idle brings the LTFT down, so assuming I have a vac leak. I am going to do a smoke test, but I think the issue lies between an...
  13. 4th Generation Chrysler Minivans: 2001-2007
    So a few weeks ago the T&C blew the upper radiator hose while driving. Replaced hose/fluid and clamps and all seemed well. Now it suddenly is running extremely rough (engine shakes violently, especially when in gear) and is leaking coolant as well (sometimes a lot, sometimes a little) from both...
  14. 2nd Generation Chrysler Minivans: 1991-1995
    Hello all- I have a 1994 caravan 4 cylinder that runs beautifully, except at idle. Most of the time, I have to shift in to neutral at a stop. Suggestions? Thank you cgobear69
  15. 4th Generation Chrysler Minivans: 2001-2007
    I can verify that the melted wires caused this same hair pulling problem P0108 I have a 2003 Dodge Caravan 3.3L engine. I was experiencing rough idle, some surging of the engine at stop and moving, rough idling at engine start with sputtering and engine dieing, with intermittent times of it...
  16. 2nd Generation Chrysler Minivans: 1991-1995
    Hi everyone, this is my first thread here, I'm looking for some help. I have a Dodge Caravan 1992 with a SOHC Engine V6 3.0L 6G72, automatic. This engine has new head gaskets, valve seals and oil retainers. Installed new fuel pump and fuel filter. Now here's the problem: During a trip to...
  17. 5th Generation Chrysler Minivans: 2008-2020
    I have a 2009 with the 3.8 with 82,000 miles on it. When at a halt and in drive it has a rough idle to where it is noticeable for even passengers. It is quite annoying.. Has anybody else had this issue and what was the remedy for it!? Thank you
  18. 2nd Generation Chrysler Minivans: 1991-1995
    I'm having problems with my 95 Plymouth Voyager... it is intermittently having a rough idle after start up until the engine warms up. Sometimes it dies before the engine warms up and I have to start it again. It only happens when it's really cold out, winter in Indiana - it was around 15...
  19. 4th Generation Chrysler Minivans: 2001-2007
    2002 Dodge grand caravan sport 3.3L, V6 Flex fuel and dodge service Manuel. I Had a staling and stumbling issue at all different speeds, along with a rough idle and received the following codes (using the A.K.A. KEY DANCE) 1.P0300 together with P0301 a. I installed the following new...
  20. 4th Generation Chrysler Minivans: 2001-2007
    ok. i have been doing my own work on my vehicles for years so I now enough to get by. so here is my issue. This is the first time it has went down. I have a 2002 dodge grand caravan sport 3.3L 204,000 miles, and bought the dealer service repair Manuel (not Haynes manuals either) it start...
1-20 of 23 Results
Top